Lincoln Navigator: Climate Control System - General Information / Specifications
LUBRICANTS, FLUIDS AND CAPACITIES
NOTE: Per the warranty and policy manual the Ford Engineering-approved refrigerant (see table for service part number) must be used for air conditioning repairs
| ITEM | CAPACITIES |
|---|---|
| US, Canada, PAG oil used with R1234YF: Material: Motorcraft® R-1234yf Refrigerant PAG Oil / YN-35 (WSS-M2C300-A2) | 3.5L EcoBoost 6.08 fl oz (179 ml) |
| Mexico, China, Asia, PAG oil used with R134a: Material: Motorcraft® PAG Refrigerant Compressor Oil / YN-12-D (WSH-M1C231-B) | 3.5L EcoBoost 6.08 fl oz (179 ml) |
| US, Canada, R1234YF refrigerant: Material: R-1234yf Refrigerant / YN-33-A (WSS-M17B21-A) | 3.5L EcoBoost, 36 - 38 oz (1.02 - 1.07 kg) |
| Mexico, China, Asia, R134a refrigerant: Material: Motorcraft® R-134a Refrigerant / YN-19 (WSH-M17B19-A) | 3.5L EcoBoost, 38 - 40 oz (1.07 - 1.13 kg) |
| Material: Motorcraft® A/C System Flushing Solvent / YN-23 | — |
| Material: Motorcraft® A/C Cooling Coil Coating / YN-29 | — |
A/C COMPRESSOR CLUTCH AIR GAP
| ITEM | MM |
|---|---|
| A/C compressor clutch air gap | 0.21 - 0.55 |
TORQUE SPECIFICATIONS
| ITEM | NM | LB-IN |
|---|---|---|
| A/C disc and hub bolt (EVDC Compressor) | 41 | 362 |
Climate Control System - Component Location. Description and Operation
Item
Description
1
Driver Side Register
2
In-Vehicle Temperature & Humidity Sensor
3
Auto Lamp & Sunload Sensor
4
Passenger Side Register
5
Center Registers
6
FCIM & HVAC Module
Item
Description
1
Air Distribution Door Actuator
2
Driver Side Register..
Other information:
Lincoln Navigator 2018-2025 Workshop Manual: Headlamp Control Module (HCM). Removal and Installation
Removal NOTE: Removal steps in this procedure may contain installation details. NOTE: If installing a new HCM (headlamp control module), it is necessary to upload the module configuration information to the scan tool prior to removing the module. This information must be downloaded into the new HCM (headlamp control module) after installation. Using a diagnostic ..
Lincoln Navigator 2018-2025 Workshop Manual: Supplemental Restraint System (SRS) Depowering. General Procedures
Depower WARNING: Incorrect repair techniques or actions can cause an accidental Supplemental Restraint System (SRS) deployment. Never compromise or depart from these instructions. Failure to precisely follow all instructions could result in serious personal injury from an accidental deployment. WARNING: Before beginning any service procedure in thi..
Categories
- Manuals Home
- 4th Gen Lincoln Navigator Service Manual (2018 - 2025)
- Body and Paint
- All Terrain Control Module (ATCM). Removal and Installation
- Front Bumper Cover. Removal and Installation
- Rear View Mirrors - System Operation and Component Description. Description and Operation
- Liftgate Trim Panel. Removal and Installation
Rear Stabilizer Bar Link. Removal and Installation
Removal
NOTE: Removal steps in this procedure may contain installation details.
With the vehicle in NEUTRAL, position it on a hoist.Refer to: Jacking and Lifting (100-02 Jacking and Lifting, Description and Operation).
NOTE: Use the hex-holding feature to prevent the stud from turning while removing the nut.
Remove and discard the 2 rear stabilizer bar link nuts and remove the rear stabilizer bar link.Torque: 46 lb.ft (63 Nm)
