Lincoln Navigator: Tire Pressure Monitoring System (TPMS) / Tire Pressure Monitoring System (TPMS) Sensor. Removal and Installation

Lincoln Navigator 2018-2026 Workshop Manual / Suspension / Tire Pressure Monitoring System (TPMS) / Tire Pressure Monitoring System (TPMS) Sensor. Removal and Installation

Removal

WARNING: The Tire Pressure Monitoring System (TPMS) sensor battery may release hazardous chemicals if exposed to extreme mechanical damage. If these chemicals contact the skin or eyes, flush immediately with water for a minimum of 15 minutes and get prompt medical attention. If any part of the battery is swallowed, contact a physician immediately. When disposing of Tire Pressure Monitoring System (TPMS) sensors, follow the correct procedures for hazardous material disposal. Failure to follow these instructions may result in serious personal injury.

NOTE: The Tire Pressure Monitoring System (TPMS) sensor cannot be removed without disassembly of the wheel and tire.
Disassemble the wheel and tire.
Refer to: Wheel and Tire (204-04A Wheels and Tires, Disassembly and Assembly).

Installation

NOTE: The Tire Pressure Monitoring System (TPMS) sensor cannot be installed without disassembly of the wheel and tire.
Assemble the wheel and tire.
Refer to: Wheel and Tire (204-04A Wheels and Tires, Disassembly and Assembly).

Tire Pressure Monitoring System (TPMS) Sensor Location Calibration. General Procedures

Special Tool(s) / General Equipment 204-D081A (204-D081) Tire Pressure Monitor (TPMS) Ford Diagnostic Equipment Programming NOTE: The TPMS can be placed into learn mode using a diagnostic scan tool or manually where a diagnostic scan tool is not available...

Vehicle Dynamic Suspension

Other information:

Lincoln Navigator 2018-2026 Workshop Manual: Intermediate Speed Sensor A (ISSA). Removal and Installation

Removal Remove the main control valve body. Refer to: Main Control Valve Body (307-01 Automatic Transmission - 10-Speed Automatic Transmission – 10R80, Removal and Installation). Remove the intermediate speed sensor A. Slide the plastic lock to the unlocked position. While pressing the plastic tab, disconnect the electrical connector. ..

Lincoln Navigator 2018-2026 Workshop Manual: Fuel Lines. Removal and Installation

Removal NOTE: Removal steps in this procedure may contain installation steps. With the vehicle in NEUTRAL, position it on a hoist. Refer to: Jacking and Lifting (100-02 Jacking and Lifting, Description and Operation). Disconnect the battery ground cable. Refer to: Battery Disconnect and Connect (414-01 Battery, Mounting and Cables, General Procedures). ..

Front Driveshaft. Removal and Installation

Special Tool(s) / General Equipment

Crimping Tool

Materials

Name Specification Motorcraft® Premium Long-Life Grease
XG-1-E1 ESA-M1C75-B

Removal

With the vehicle in NEUTRAL, position the vehicle on a hoist.
Refer to: Jacking and Lifting (100-02 Jacking and Lifting, Description and Operation).
Remove the bolts and the transmission shield.