Lincoln Navigator: Driveshaft / Specifications
Lubricants, Fluids, Sealers and Adhesives
| Item | Specifications |
|---|---|
| Motorcraft® Premium Long-Life Grease / XG-1-E1 | ESA-M1C75-B |
2WD (Two-Wheel Drive) U-joint Operating Angles
| Item | Front U joint | Center U joint | Rear U joint | |
|---|---|---|---|---|
| SWB | 9.75" Ring Gear Axle | 0.3° | 0.4° | 0.3° |
| LWB | 9.75" Ring Gear Axle | 0.8° | 0.6° | 0.3° |
4WD (Four-Wheel Drive) U-joint Operating Angles
| Item | Front U joint | Rear U joint | |
|---|---|---|---|
| SWB | 9.75" Ring Gear Axle | 0.7° | 0.3° |
| LWB | 9.75" Ring Gear Axle | 1.5° | 0.4° |
| Item | Specifications |
| Drive pinion flange runout | 0.279 mm (0.012 in) |
| Maximum allowable driveshaft runout | 0.5 mm (0.02 in) |
| Front driveshaft runout | 0.76 mm (0.03 in) |
| U-joint maximum operating angle | 1.5° |
Torque Specifications
| Item | Nm | lb-ft | lb-in |
|---|---|---|---|
| Center bearing support bolts | 48 | 35 | - |
| Muffler inlet pipe clamp | 48 | 35 | - |
| Rear driveshaft-to-pinion flange bolts | 103 | 76 | - |
Driveshaft
..
Driveshaft. Diagnosis and Testing
Symptom Chart(s)
Diagnostics in this manual assume a certain skill level and knowledge of Ford-specific diagnostic practices.REFER to: Diagnostic Methods (100-00 General Information, Description and Operation)...
Other information:
Lincoln Navigator 2018-2026 Workshop Manual: Differential Carrier. Removal and Installation
Special Tool(s) / General Equipment 100-002 (TOOL-4201-C) Holding Fixture with Dial Indicator Gauge 205-001 (TOOL-4000-E) Spreader, Differential Carrier 205-335 (T93P-4000-A) Spreader, Differential Housing (Plate)TKIT-1993-FLMTKIT-1993-LMTKIT-1996-F/FM 205-368 (T96T-4000-A) Adapter for Differential Housing SpreaderTKIT-1998-LM (NavigatoR..
Lincoln Navigator 2018-2026 Workshop Manual: Keyless Entry Keypad. Removal and Installation
Removal NOTE: The keyless entry keypad is serviced as an assembly with the front door upper moulding. Remove the front door upper moulding. Refer to: Front Door Upper Moulding (501-08 Exterior Trim and Ornamentation, Removal and Installation). Installation To install, reverse the removal procedure. Carry out the power door windo..
Categories
- Manuals Home
- 4th Gen Lincoln Navigator Service Manual (2018 - 2026)
- Liftgate Trim Panel. Removal and Installation
- Head Up Display (HUD) Module Calibration. General Procedures
- Rear View Mirrors - System Operation and Component Description. Description and Operation
- Windshield Washer Pump. Removal and Installation
- Body and Paint
Rear Drive Halfshafts. Diagnosis and Testing
Preliminary Inspection
Visually inspect the CV joints, housing, boots, and clamps for obvious signs of mechanical damage.If an obvious cause for an observed or reported concern is found, correct the cause (if possible) before proceeding to the next step
If the cause is not visually evident, verify the symptom and REFER to Symptom Chart: NVH.
